What is the maintenance schedule for a E-Z-GO RXV EX1 EFI (Gas)?

The E-Z-GO RXV EX1 EFI (Gas) is serviced on engine hours, not miles. Key intervals include Brake Shoes Inspect (every 10 hours), Parking Brake Performance Test (every 20 hours), Controller Braking Force Check (every 20 hours). Track the hour meter and service each item when its interval comes due.

Does the E-Z-GO RXV EX1 EFI (Gas) track maintenance by hours or miles?

By hours. Small engines and heavy equipment log run time on an hour meter, so their service intervals are hours-based. ServiceSage Auto tracks the E-Z-GO RXV EX1 EFI (Gas) by hours and reminds you when each service is due.

E-Z-GO RXV EX1 EFI (Gas) Maintenance Schedule

E-Z-GO RXV EX1 EFI (Gas) maintenance — the short answer

Oil: SAE 5W-30 · 1.6 qt (1.5 L)
Engine: EX1 EFI - 4-stroke, OHV, single cylinder, air cooled, closed-loop EFI, 11.5 hp (8.6 kW), electronic inductive (magneto) ignition, positive-displacement oil pump with full-flow oil screen (no oil filter)
Tracked by: engine hours, not miles

E-Z-GO RXV EX1 EFI (Gas) maintenance schedule by engine hours

Interval	Service	Details
Every 10 hours	Brake Shoes Inspect	Inspect brake shoes and replace as needed.
Every 20 hours	Parking Brake Performance Test	Conduct brake performance test and adjust the parking brake as necessary.
Every 20 hours	Controller Braking Force Check	Check operation of controller braking force.
Every 20 hours	Wiring Inspect	Inspect wiring for loose connections, broken or missing insulation.
Every 20 hours	Direction Selector Adjust	Inspect attachment and mechanism; adjust as necessary.
Every 20 hours	Steering Play Check	Check steering for excess play, loose or missing hardware.
Every 20 hours	Tie Rods Check	Check tie rods for excess play, bent rods, loose or missing hardware.
Every 20 hours	Engine General Check	Check engine for unusual noise, vibration, acceleration issues, or oil leaks.
Every 20 hours	Rear Axle Leak Check	Check rear axle for leakage; add oil as required.
Every 50 hours	General Lubrication	Lubricate all fittings, pivots, cables, etc. where required.
Every 50 hours	Engine Electrical System Check	Check ignition coil/spark plug wires for cracks or loose connections.
Every 50 hours	Throttle/Governor Linkage Check	Check throttle/governor linkage operation and governed speed.
Every 50 hours	Fuel System Leak Check - 50 Hour	Emission-related check for leakage at tank, cap, lines, filters, pump, and fuel rail.
Every 50 hours	Front Axle Check	Check front axle for damage, loose or missing hardware.
Every 50 hours	Front Wheel Alignment Check	Inspect for unusual tire wear; align if necessary.
Every 125 hours	Engine Oil Level Check	Check the engine oil level; add as necessary.
Every 125 hours	Air Filter Inspect/Clean	Emission-related service: inspect and clean the air filter as necessary.
Every 125 hours	Battery Terminal Inspection	Inspect and clean battery terminals as needed.
Every 125 hours	CVT Belt Inspect	Inspect the CVT (clutch) belt for cracks, fraying and excessive wear.
Every 125 hours	CVT Filter Inspect/Clean	Inspect and clean the CVT housing filter as needed.
Every 125 hours	King Pins Check	Check king pins for excessive play and tight retaining nuts.
Every 125 hours	Rear Axle Inspection	Check the rear axle for unusual noise, loose or missing hardware.
Every 125 hours	Direction Selector Lubricate	Check for wear and smooth movement; lubricate shaft with light oil if necessary.
Every 125 hours	Steering Bellows/Pinion Seal Inspect	Inspect steering bellows and pinion seal for damage and leakage.
Every 125 hours	Rack End Ball Joint Check	Check rack end ball joint for noise and loose or missing hardware.
Every 300 hours	Muffler/Exhaust System Check	Check exhaust for leaks and check the graphite joint integrity.
Every 300 hours	Blow-by PVC Drain	Emission-related service: drain the PVC drain tube.
Every 300 hours	Fuel System Leak Check - 300 Hour	Emission-related recheck for leakage at tank, cap, lines, filters, pump, fuel rail.
Every 300 hours	Carbon Canister Check	Emission-related service: check canister hoses for cracks and check connections/clamps.
Every 500 hours	Spark Plug Replace	Emission-related service: replace the spark plug (NGK CR6HSA) and gap it new.
Every 500 hours	Transaxle and Differential Oil Level Check	Check the transaxle/differential oil level and add oil as needed.
Every 500 hours	Cylinder Head/Piston Carbon Removal	Dealer service: remove carbon buildup from the cylinder head and piston.
Every 500 hours	Valve Seat Carbon Check	Dealer service: check valve seats for carbon buildup and clean if necessary.
Every 500 hours	Rear Axle Fluid Replace	Dealer service: replace rear axle fluid.
Every 500 hours	CVT Rollers Inspect	Dealer service: inspect CVT rollers.
Every 1,000 hours	Valve Clearance Adjust	Dealer service: check intake/exhaust valve clearance cold and adjust if needed.
Every 1,000 hours	CVT Slipper Shoe Inspect	Dealer service: inspect the CVT slipper shoe.
Every 1,000 hours	CVT Rollers Replace	Dealer service: replace CVT rollers.

E-Z-GO RXV EX1 EFI (Gas) specifications

Type: Golf Cart
Engine: EX1 EFI - 4-stroke, OHV, single cylinder, air cooled, closed-loop EFI, 11.5 hp (8.6 kW), electronic inductive (magneto) ignition, positive-displacement oil pump with full-flow oil screen (no oil filter)
Displacement: 150 cc (9.15 cu in)
Oil type: SAE 5W-30
Oil capacity: 1.6 qt (1.5 L)
Spark plug: NGK CR6HSA; E-Z-GO service part number 696497 is the packaged number for this same plug

E-Z-GO RXV EX1 EFI (Gas) items without a fixed hour interval

Air Filter Pre-Ride Check: Pre-ride: inspect air filter and clean or replace as needed.