The 2024 Ford Super Duty belongs to the 4th generation (2023 refresh) (2023-present), built with 7.3L Godzilla V8 gas, 6.8L V8 gas (new, replaces the 6.2L), or the 6.7L Power Stroke V8 diesel (standard 475 hp/1,050 lb-ft, or a new High Output 500 hp/1,200 lb-ft tune) - every engine on the 10R140 10-speed. It takes 5W-30 full synthetic (7.3L Godzilla and 6.8L V8, both WSS-M2C961-A1 - the 6.8L is a destroked 7.3L Godzilla derivative and shares its spec); Motorcraft diesel motor oil options (6.7L Power Stroke, standard or High Output). Oil changes run up to 10,000 miles/12 months (gas) or 15,000 miles/12 months (diesel), set by the oil life monitor per the 2024 owner's manual. This sits in the middle of the generation run, generally the most sorted point in a design before end-of-run cost reductions.
A 2024 Ford Super Duty is 2 years old in 2026, which at an average 12,000 miles a year puts it around 24,000 miles - early ownership. Around 24,000 miles you are into cabin and engine air filters, brake fluid on a time basis, and the first brake pad inspections. Costs are still low, which makes this the cheapest period to stay ahead of the schedule rather than catch up on it. On that mileage estimate the next milestone is 30,000 miles - engine air filter, cabin filter and a brake inspection - roughly 1 years away at average use.
The fault most worth knowing about on this generation is Software/infotainment teething issues typical of a fully redesigned electrical architecture. Owners also report First-model-year risk on the 6.8L V8 and the High Output 6.7L tune, both new for 2023 with limited multi-year fleet data as of this pass; and EGR cooler fouling/failure remains a longstanding Power Stroke-family risk carried into the 3rd-gen block. None of these are certainties on any individual vehicle - they are the patterns worth checking for when you buy or when a symptom appears.
Track your 2024 Ford Super Duty service history free with the ServiceSage maintenance tracker, or compare it against other model years on the Ford Super Duty maintenance schedule hub.
| Interval | Service |
|---|---|
| Every 7,500 mi (or IOLM signal; gas V8) | Oil & filter change - grade and capacity per your engine (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Check all fluid levels |
| Every 10,000 mi (or IOLM signal; 6.7L Power Stroke diesel, normal duty) | Oil & filter change - Motorcraft diesel-spec oil (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Drain water from the fuel/water separator |
| Every 5,000 mi (severe duty: towing, trailer, extensive idling, off-road, dusty conditions - all engines) | Oil & filter change on the shortened interval - do not stretch past this while towing or plowing regularly, Tire rotation, Inspect brake pads (towing accelerates wear) |
| Every 20,000 mi | Replace cabin air filter, Inspect brake pads & rotors, Inspect front suspension bushings and ball joints - a heavier front end than a half-ton truck |
| Every 22,500 mi (6.7L Power Stroke diesel - fuel filters, normal duty) | Replace both fuel filters (chassis-mounted fuel/water separator and engine-mounted secondary) - 6.7L Power Stroke |
| Every 15,000 mi (6.7L Power Stroke diesel, severe duty or B20 biodiesel blends, or every 6 months whichever comes first) | Replace both fuel filters on the shortened interval - 6.7L Power Stroke |
| Every 30,000 mi | Inspect/replace engine air filter (gas engines), Inspect drive belt condition, Inspect coolant condition and hoses |
| Every 36 months (brake fluid) | Replace brake fluid - Motorcraft DOT 3 LV or DOT 4 LV |
| Every 45,000 mi (6.7L Power Stroke diesel) | Replace the CCV (crankcase ventilation) oil separator - 6.7L Power Stroke, Inspect turbocharger boost hoses and clamps - 6.7L Power Stroke, Coolant flush and refill on the recurring interval for the 6.7L Power Stroke (the first flush lands at a longer mileage under normal duty - see coolant field above; severe-duty trucks are on this interval from the start) |
| Every 60,000 mi (severe duty: towing/trailering/plowing - transmission, transfer case, differentials) | Automatic transmission fluid service - Mercon LV (6R140 six-speed) or Mercon ULV (10R140 ten-speed); the two are not interchangeable, Transfer case fluid change (4x4), Front and rear differential fluid change |
| Every 100,000 mi (7.3L V8 spark plugs) | Replace all 8 spark plugs (1 per cylinder) |
| Every 100,000 mi (6.8L V8 spark plugs) | Replace all 8 spark plugs (1 per cylinder) |
| Every 100,000 mi | Rear differential fluid change (normal duty), Inspect water pump and serpentine belt |
| Every 105,000 mi (6.7L Power Stroke diesel - first coolant service, normal duty) | First coolant flush and refill for the 6.7L Power Stroke - Motorcraft coolant (see coolant field above); much sooner under severe duty (see the 45,000 mi severe-duty row) |
| Every 150,000 mi | Automatic transmission fluid service (normal duty), Transfer case fluid change (normal duty, 4x4), Front differential fluid change (normal duty, 4x4) |
| Every 250,000 mi (6.7L Power Stroke diesel - DPF ash service) | Diesel particulate filter (DPF) ash service for the 6.7L Power Stroke - a dealer regeneration/cleaning procedure, not owner-serviceable; a dash service light indicates when it is due |
The table above is indexed by service interval. This is the same schedule indexed by odometer reading, for when you know your mileage and want the list. If your odometer sits between these figures, work back to the last one you passed and catch up anything skipped.
| Odometer | Service due |
|---|---|
| 30,000 mi (48,000 km) | Oil & filter change - grade and capacity per your engine (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Check all fluid levels, Oil & filter change - Motorcraft diesel-spec oil (see oil type/capacity above), Drain water from the fuel/water separator, Inspect/replace engine air filter (gas engines), Inspect drive belt condition, Inspect coolant condition and hoses. |
| 60,000 mi (97,000 km) | Oil & filter change - grade and capacity per your engine (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Check all fluid levels, Oil & filter change - Motorcraft diesel-spec oil (see oil type/capacity above), Drain water from the fuel/water separator, Replace cabin air filter, Inspect brake pads & rotors, Inspect front suspension bushings and ball joints - a heavier front end than a half-ton truck, Inspect/replace engine air filter (gas engines), Inspect drive belt condition, Inspect coolant condition and hoses. |
| 90,000 mi (145,000 km) | Oil & filter change - grade and capacity per your engine (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Check all fluid levels, Oil & filter change - Motorcraft diesel-spec oil (see oil type/capacity above), Drain water from the fuel/water separator, Replace both fuel filters (chassis-mounted fuel/water separator and engine-mounted secondary) - 6.7L Power Stroke, Inspect/replace engine air filter (gas engines), Inspect drive belt condition, Inspect coolant condition and hoses, Replace the CCV (crankcase ventilation) oil separator - 6.7L Power Stroke, Inspect turbocharger boost hoses and clamps - 6.7L Power Stroke, Coolant flush and refill on the recurring interval for the 6.7L Power Stroke (the first flush lands at a longer mileage under normal duty - see coolant field above; severe-duty trucks are on this interval from the start). |
| 100,000 mi (161,000 km) | Oil & filter change - Motorcraft diesel-spec oil (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Drain water from the fuel/water separator, Replace cabin air filter, Inspect brake pads & rotors, Inspect front suspension bushings and ball joints - a heavier front end than a half-ton truck, Replace all 8 spark plugs (1 per cylinder), Rear differential fluid change (normal duty), Inspect water pump and serpentine belt. The every-7,500 mi service runs on its own cycle - the nearest fall at 97,500 and 105,000 miles. |
| 120,000 mi (193,000 km) | Same as the 60,000 mi service. |
| 150,000 mi (241,000 km) | Oil & filter change - grade and capacity per your engine (see oil type/capacity above), Tire rotation, Inspect brakes, belts, hoses, and driveline U-joints, Check all fluid levels, Oil & filter change - Motorcraft diesel-spec oil (see oil type/capacity above), Drain water from the fuel/water separator, Inspect/replace engine air filter (gas engines), Inspect drive belt condition, Inspect coolant condition and hoses, Automatic transmission fluid service (normal duty), Transfer case fluid change (normal duty, 4x4), Front differential fluid change (normal duty, 4x4). |
| 200,000 mi (322,000 km) | Same as the 100,000 mi service. The every-7,500 mi service runs on its own cycle - the nearest fall at 195,000 and 202,500 miles. |
| Fastener | Torque | Size |
|---|---|---|
| Lug nut | 150 ft-lbs (204 Nm) | 13/16in |
| Spark plug | 11 ft-lbs (15 Nm) | 5/8in |
Maintenance keeps these away, but when the dash does light up these are the codes this vehicle throws most often - each with what it means and what the repair actually costs.